Product ID:SKD-NF/ZP-9B DEVELOPER, (NEW FORMULATION)
MSDS Date:05/26/1989
FSC:6850
NIIN:00-826-0981
Kit Part:Y
MSDS Number: BHMWH

MAGNAFLUX CORPORATION

7300 W. LAWRENCE AVENUE
CHICAGO, IL 60656-3504
US

Emergency Phone: 312-867-8000

Info Phone: 312-867-8000

Preparer: BRUCE C. GRAHAM

Cage: 37676

ILLINOIS TOOL WORKS INC MAGNAFLUX DIV

GLENVIEW, IL 60025 US

Telephone: 847-657-5300/

Cage: 37676

METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)

CAS: 71-55-6

RTECS: KJ2975000

Fraction By Weight: 90.0%

OSHA PEL 350 PPM/450 STEL

ACGIH TLV: 350 PPM/450STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYLAL (DIMETHOXYMETHANE)

CAS: 109-87-5

RTECS: PA8750000

Fraction By Weight: 2%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM; 9192

TERT-BUTYL ALCOHOL (SARA III)

CAS: 75-65-0

RTECS: EO1925000

Fraction By Weight: 1 - 3%

OSHA PEL 100 PPM

ACGIH TLV: 100PPM 9394

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Explanation of Carcinogenicity:THIRD LISTED INGREDIENT HAS BEEN UNDER
INVESTIGATION AS A POSSIBLE CARCINOGEN.
Effects of Overexposure:INHAL: DIZZ, DROWS, NAUSEA. UNCONSCIOUS AT HIGH
EXPOSURE. SKIN: IRRI BY DISSOLVING SKIN OILS. NOT ABSORBED THROUGH
IN SIGNIFICANT AMOUNTS EYES: IRRITATING DUE TO STRONG SOLVENT
ACTION. AND INGESTION: LOW SINGLE DOSE TOXICITY IN TEST ANIMALS
Medical Cond Aggravated by Exposure:NONE

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, CALL EMERGENCY
IMMED. GIVE CPR/OXYGEN, IF BREATHING IS DIFF. SKIN: WASH OFF IN
FLOWING WATER/SHOWER. REMOVE CONTAMCLOTHES & LAUNDER. USE SOOTHING
LOTION. EYE: FLUSH EYE WITH STEADY, GENTLE FLOWOF WATER, LIFTING
LIDS. ROLLING EYEBALL ALL DIRECTIONS. INGESTION: DO NOT
INDUCEVOMIT; IF VOMIT IS INHALED, MAY CAUSE ASPHYXIATION. CONTACT
PHYSICIAN IMMED

Flash Point:NONE
Extinguishing Media:USE SUITABLE EXTINGUISHING MEDIA FOR SURROUNDING
FIRES.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS PARTIALLY DECOMPOSE TO TOXIC GASES
WHEN EXPOSED TO FLAME,ARCS,OR RED HOT SURFACES; AEROSOL CANS MAY
BURST AT TEMPERATURE OVER 130F.

Spill Release Procedures:CLEAN UP CREW SHOULD WEAR ALL PERSONAL SAFETY
WEARAS PRESENTED. THE NOSE IS NOT A RELIABLE GAUGE OF AIR
CONTAMINATION. DO NOT BREATHE VAPORS. AVOID PROLONGED/REPEATED
EXPOSURE. DO NOT USE AROUND INGNITION SOURCES.

Handling and Storage Precautions:DO NOT HEAT AEROSOL CANS ABOVE 130F TO
ELIMINATE POSSIBLE BURSTING/RELEASING UNWANTED VAPORS. STOREAWAY
FROM HEAT SOURCES.
Other Precautions:IMPORTANT: IN ALL SEVERE CASES, CONTACT PHYSICIAN
IMMED. LOCAL TELEPHONE OPERAT-ORS. ARE ABLE TO FURNISH NUMBER OF
REGIONAL POISON CONTROL CENTER TO ASSIST PHYSICIAN.

Respiratory Protection:IN POORLY VENT AREAS SUCH AS SMALL ROOMS WITH NO
WINDOWS OR IN SUMPS, OTHER LOW AREAS (SKD-NF VAPORS ARE DENSE &
SINK TO LOW SPOTS) THE USER SHOULD WEAR A RESPIRATOR WITH CHEMICAL
CARTRIDGE. CONFINED: FULL MASK W/SEPARATE AIR SUPPLY
Ventilation:GENERAL VENTILATION MUST BE SUFFICIENT TO KEEP THE
CONCENTRATION BELOW 350 PPM. BASE VENT RATE ON CONSUMPTION.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Work Hygienic Practices:GOOD HYGIENE PRACTICES
Supplemental Safety and Health
NK

HCC:T4
Vapor Pres:230MM @100
Vapor Density:4.0
Spec Gravity:1.3
pH:7.0LIQ
Evaporation Rate & Reference:3.0(ETHYL ALCOHOL=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS,MOBIL LIQUID IN AEROSOL CANS UNDER
PRESSURE.

Stability Indicator/Materials to Avoid:YES
POWDERED ZINC AND ALUMINUM
Stability Condition to Avoid:HIGH TEMPERATURE/HEAT.
Hazardous Decomposition Products:PHOSGENE, HYDROCHLORIC ACID-EXTREMELY
TOXIC TLV 0.1 PPM CANNOT BE RELIABLY DETECTED BY ODOR. HYDROCHORIC
CAN, IS IRRI

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002. MAY BE
SENT TO SOLVENT RECLAIMER. ENSURE THAT AEROSOL CANS ARE EMPTY &
DEPRESSURIZED BEFORE DISCARDING,UNLESSWASTE TREATMENT FACILITY IS
APPROVED TO ACCEPT THEM AS IS

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.